JWARP  Vol.7 No.16 , November 2015
pH Control during the Struvite Precipitation Process of Wastewaters
ABSTRACT
The high concentration of phosphorus and nitrogen in wastewater and sludge could be lowered to a certain level by struvite (MgNH4PO4·6H2O) crystallization. One of the main factors for struvite formation is the solution pH. It can be adjusted by non-reagent carbon (CO2) dioxide stripping through the process of aeration. The intensity of the mass transfer between the air and the supernatant of dewatering sludge obtained from wastewater treatment plant is characterized by the volumetric liquid-side mass transfer coefficient, which can be estimated theoretically. It is found that the rate of pH increase depends strongly on the sparging area of the air distribution system while the air flow rate does not influence considerably the Dissolved Oxygen (DO) level which governs the CO2 stripping process. The theoretical calculated values of the volumetric mass transfer coefficient have been compared with those obtained experimentally. Based on the data obtained, relationships of pH/kLa (mass transfer coefficient) were developed. These correlations serve as a tool for prediction of pH during the struvite precipitation process.

Cite this paper
Radev, D. , Peeva, G. and Nenov, V. (2015) pH Control during the Struvite Precipitation Process of Wastewaters. Journal of Water Resource and Protection, 7, 1399-1408. doi: 10.4236/jwarp.2015.716113.
References
[1]   Deng, L.W., Zheng, P. and Chen, Z.A. (2006) Anaerobic Digestion and Post-Treatment of Swine Wastewater Using IC-SBR Process with Bypass of Raw Wastewater. Process Biochemistry, 41, 965-969.
http://dx.doi.org/10.1016/j.procbio.2005.10.022

[2]   Khan, F.A. and Ansari, A.A. (2005) Eutrophication: An Ecological Vision. The Botanical Review, 71, 449-482.
http://dx.doi.org/10.1663/0006-8101(2005)071[0449:EAEV]2.0.CO;2

[3]   Lee, S.I., Weon, S.Y., Lee, C.W. and Koopman, B. (2003) Removal of Nitrogen and Phosphate from Wastewater by Addition of Bittern. Chemosphere, 51, 265-271.
http://dx.doi.org/10.1016/S0045-6535(02)00807-X

[4]   Welander, U., Henrysson, T. and Welander, T. (1998) Biological Nitrogen Removal from Municipal Landfill Leachate in a Pilot Scale Suspended Carrier Biofilm Process. Water Research, 32, 1564-1570.
http://dx.doi.org/10.1016/S0043-1354(97)00351-5

[5]   Liu, Y.H., Kwag, J.H., Kim, J.H. and Ra, C.S. (2011) Recovery of Nitrogen and Phosphorus by Struvite Crystallization from Swine Wastewater. Desalination, 277, 364-369.
http://dx.doi.org/10.1016/j.desal.2011.04.056

[6]   Cho, J.H., Lee, J.E. and Ra, C.S. (2009) Microwave Irradiation as a Way to Reutilize the Recovered Struvite Slurry and to Enhance System Performance. Journal of Animal Science and Technology (Korea), 51, 337-342.
http://dx.doi.org/10.5187/JAST.2009.51.4.337

[7]   Rahman, M.M., Liu, Y.H., Kwag, J.H. and Ra, C.S. (2011) Recovery of Struvite from Animal Wastewater and Its Nutrient Leaching Loss in Soil. Journal of Hazardous Materials, 186, 2026-2030.
http://dx.doi.org/10.1016/j.jhazmat.2010.12.103

[8]   Münch, E.V. and Barr, E. (2001) Controlled Struvite Crystallisation for Removing Phosphorus from Anaerobic Digester Sidestreams. Water Research, 35, 151-159.
http://dx.doi.org/10.1016/S0043-1354(00)00236-0

[9]   Laridi, R., Auclair, J.C. and Benmoussa, H. (2005) Laboratory and Pilot-Scale Phosphate and Ammonium Removal by Controlled Struvite Precipitation Following Coagulation and Flocculation of Swine Wastewater. Environmental Technology, 26, 525-536.
http://dx.doi.org/10.1080/09593332608618533

[10]   Abbona, F. and Boistelle, R. (1979) Growth Morphology and Crystal Habit of Struvite Crystals (MgNH4PO4·6H2O). Journal of Crystal Growth, 46, 339-354.
http://dx.doi.org/10.1016/0022-0248(79)90082-4

[11]   Ohlinger, K.N., Young, T.M., Schroeder, E.D. (1999) Kinetics Effects on Preferential Struvite Accumulation in Waste-water. Journal of Environmental Engineering, 125, 730-737.
http://dx.doi.org/10.1061/(ASCE)0733-9372(1999)125:8(730)

[12]   Hao, X.D., Wang, C.C., Lan, L. and Loosdrecht, M.C.M.V. (2008) Struvite Formation, Analytical Methods and Effects of pH and Ca2+. Water Science and Technology, 58, 1687-1692.

[13]   El Diwani, G., El Rafie, Sh., El Ibiari, N.N. and El-Aila, H.I. (2007) Recovery of Ammonia Nitrogen from Industrial Wastewater Treatment as Struvite Slow Releasing Fertilizer. Desalination, 214, 200-214.
http://dx.doi.org/10.1016/j.desal.2006.08.019

[14]   Stratful, I., Scrimshaw, M. and Lester, J. (2001) Conditions Influencing the Precipitation of Magnesium Ammonium Phosphate. Water Research, 35, 4191-4199.
http://dx.doi.org/10.1016/S0043-1354(01)00143-9

[15]   Battistoni, P., de Angelis, A., Pavan, P., Prisciandaro, M. and Cecchi, F. (2001) Phosphorus Removal from a Real Anaerobic Supernatant by Struvite Crystallization. Water Research, 35, 2161-2178.
http://dx.doi.org/10.1016/S0043-1354(00)00498-X

[16]   Zeng, L. and Li, X. (2006) Nutrient Removal from Anaerobically Digested Cattle Manure by Struvite Precipitation. Journal of Environmental Engineering and Science, 5, 285-294.
http://dx.doi.org/10.1139/s05-027

[17]   Williams, S. (1999) Struvite Precipitation in the Sludge Stream at Slough Wastewater Treatment Plant and Opportunities for Phosphorus Recovery. Environmental Technology, 20, 743-747.
http://dx.doi.org/10.1080/09593332008616869

[18]   Song, Y.H., Qiu, G.L., Yuan, P., Cui, X.Y., Peng, J.F., Zeng, P., Duan, L., Xiang, L.C. and Qian, F. (2011) Nutrients Removal and Recovery from Anaerobically Digested Swine Wastewater by Struvite Crystallization without Chemical Additions. Journal of Hazardous Materials, 190, 140-149.
http://dx.doi.org/10.1016/j.jhazmat.2011.03.015

[19]   Ohlinger, K.N., Young, T.M. and Schroeder, E.D. (1998) Predicting Struvite Formation in Digestion. Water Research, 32, 3607-3614.
http://dx.doi.org/10.1016/S0043-1354(98)00123-7

[20]   Summerfelt, S.T., Vinci, B.J. and Piedrahita, R.H. (2000) Oxygenation and Carbon Dioxide Control in Water Reuse Systems. Aquacultural Engineering, 22, 87-108.
http://dx.doi.org/10.1016/S0144-8609(00)00034-0

[21]   Shanableh, A. (2009) Carbon Dioxide Transfer with Chemical Equilibrium Reactions: An Alternative Mathematical Approach. American Journal of Engineering and Applied Sciences, 2, 726-734.

[22]   Nedelchev, S. and Jordan, U. (2006) A New Correction Factor for Theoretical Prediction of Mass Transfer Coefficients in Bubble Columns. Journal of Chemical Engineering of Japan, 39, 1237-1242.
http://dx.doi.org/10.1252/jcej.39.1237

[23]   Ivanov, Zh., Stefanov, Zh. and Bogdanov, B. (2011) Gas-Side Mass Transfer Coefficient of Laboratory Column Equipped with One Sieve Tray. Proceedings: Chemical Technologies, 50, 51-55.

[24]   Fan, L.S. and Tsuchiya, K. (1990) Butterworth-Heinemann Series in Chemical Engineering, Stoneham, U.S.A.

[25]   Terasaka, K., Inoue, Y., Kakizaki, M. and Niwa, M. (2004) Simultaneous Measurement of 3-Dimensional Shape and Behavior of Single Bubble in Liquid Using Laser Sensors. Journal of Chemical Engineering of Japan, 37, 921-926.
http://dx.doi.org/10.1252/jcej.37.921

[26]   Budesinsky, B.W. (1975) A Simultaneous EDTA-Metric Determination of Calcium and Magnesium with Antipyrylazo III and Thymolphthalexon. Microchemical Journal, 20, 17-21.
http://dx.doi.org/10.1016/0026-265X(75)90107-1

[27]   Higbie, R. (1935) The Rate of Absorption of a Pure Gas into a Still Liquid during Short Periods of Exposure. Transactions of the AIChE, 31, 365-389.

[28]   Mendelson, H.D. (1967) The Prediction of Bubble Terminal Velocities from Wave Theory. AIChE Journal, 13, 250-253.
http://dx.doi.org/10.1002/aic.690130213

[29]   Georgiev, D. and Vlaev, S.D. (2012) Bioprocess Improvement by Design-Modified Bioreactor Flow Properties. Biotechnology & Biotechnological Equipment, 26, 3182-3186.
http://dx.doi.org/10.5504/BBEQ.2012.0031

[30]   Miller, D.N. (1974) Scale-Up of Agitated Vessels Gas-Liquid Mass Transfer. AIChE Journal, 20, 445-453.
http://dx.doi.org/10.1002/aic.690200303

[31]   Painmanakul, P., Loubiere, K., Hebrard, G., Mietton-Peuchot, M. and Roustan, M. (1999) Dynamics of Gas-Liquid Flows in Bubble Column Reactors. Chemical Engineering Science, 54, 5237-5243.
http://dx.doi.org/10.1016/S0009-2509(99)00245-6

[32]   Wilkinson, P.M. and Haringa, H. (1994) Mass Transfer and Bubble Size in a Bubble Column under Pressure. Chemical Engineering Science, 49, 1417-1427.
http://dx.doi.org/10.1016/0009-2509(93)E0022-5

[33]   Fattah, K.P., Mavinic, D.S., Koch, F.A. and Jacob, C. (2008) Determining the Feasibility of Phosphorus Recovery as Struvite from Filter Press Centrate in a Secondary Wastewater Treatment Plant. Journal of Environmental Science and Health Part A, 43, 756-764.

[34]   Uysala, A., Yilmazel, Y.D. and Demirer, G.N. (2010) The Determination of Fertilizer Quality of the Formed Struvite from Effluent of a Sewage Sludge Anaerobic Digester. Journal of Hazardous Materials, 181, 248-254.
http://dx.doi.org/10.1016/j.jhazmat.2010.05.004

 
 
Top