JPEE  Vol.3 No.8 , August 2015
Fuel Gas Production from Biomass Sources by Radio Frequency In-Liquid Plasma Method
Abstract: Cellulose is a kind of saccharide that is the main component in cell walls of plants and therefore is the organic compound that exists in the largest amount in nature. The purpose of this experiment is to convert cellulose to a fuel. Radio frequency (RF) in-liquid plasma is generated in a cellulose distributed solution and a glucose solution, and the generation gas rate is measured. While hydrogen is the main gas generated by the plasma breakdown, carbon monoxide, carbon dioxide, and low-grade flammable gases are also produced. In the glucose water solution or the glucose distributed solution, the solution itself evaporates and decomposes inside the plasma but since the saccharides are non-volatile, they cannot penetrate into the plasma and are not decomposition. However, when the cellulose is at concentrations of 30 wt% or more, it becomes granular and can directly enter the plasma as a solid, where the plasma decomposes the cellulose itself, significantly increasing the amount of gas generated. In addition, the spectrometry of the plasma emission shows the solution after the creation of plasma has the ability to absorb ultraviolet light.
Cite this paper: Rahim, I. , Nomura, S. , Mukasa, S. , Toyota, H. , Kawanishi, K. , Makiura, Y. , Kogoh, K. , Ohshima, K. and Katsuen, S. (2015) Fuel Gas Production from Biomass Sources by Radio Frequency In-Liquid Plasma Method. Journal of Power and Energy Engineering, 3, 28-35. doi: 10.4236/jpee.2015.38004.

[1]   De Souza, R.L., Yu, H., Rataboul, F. and Essayem, N. (2012) 5-Hydroxymethylfurfural (5-HMF) Production from Hexoses: Limits of Heterogeneous Catalysis in Hydrothermal Conditions and Potential of Concentrated Aqueous Organic Acids as Reactive Solvent System. Challenges, 3, 212-232.

[2]   Lai, L. and Zhang, Y. (2011) The Production of 5-Hydroxymethylfurfural from Fructose in Isopropyl Alcohol: A Green and Efficient System. ChemSusChem, 4, 1745-1748.

[3]   Tong, X., Ma, Y. and Li, Y. (2010) Biomass into Chemicals: Conversion of Sugars to Furan Derivatives by Catalytic Processes. Applied Catalysis A, 385, 1-13.

[4]   Kazi, F.K., Patel, A.D., Serrano-Ruiz, J.C., Dumesic, J.A. and Anex, R.P. (2011) Techno-Economic Analysis of Dimethylfuran (DMF) and Hydroxymethylfurfural (HMF) Production from Pure Fructose in Catalytic Processes. Chemical Engineering Journal, 169, 329-338.

[5]   Kawashima, A., Matsubara, K. and Honda, K. (2008) Development of Heterogeneous Base Catalysts for Biodiesel Production. Bioresource Technology, 99, 3439-3443.

[6]   Kawashima, A., Matsubara, K. and Honda, K. (2009) Acceleration of Catalytic Activity of Calcium Oxide for Biodiesel Production. Bioresource Technology, 100, 696-700.

[7]   Brethauer, S. and Wyman, C.E. (2010) Continuous Hydrolysis and Fermentation for Cellulosic Ethanol Production. Bioresource Technology, 101, 4862-4874.

[8]   Chundawat, S.P., Bellesia, G., Uppugundla, N., da Costa Sousa, L., Gao, D., Cheh, A.M., Agarwal, U.P., Bianchetti, C.M., Phillips Jr., G.N., Langan, P., Balan, V., Gnanakaran, S. and Dale, B.E. (2011) Restructuring the Crystalline Cellulose Hydrogen Bond Network Enhances Its Depolymerization Rate. Journal of the American Chemical Society, 133, 11163-11174.

[9]   Nishiyama, Y., Lngan, P. and Chanzy, H. (2002) Crystal Structure and Hydrogen-Bonding System in Cellulose Iβ from Synchrotron X-Ray and Neutron Fiber Diffraction. Journal of the American Chemical Society, 124, 9074-9082.

[10]   Xiang, Q., Lee, Y.Y., Pettersson, P.O. and Torget, R.W. (2003) Heterogeneous Aspects of Acid Hydrolysis of α-Cellulose. Applied Biochemistry and Biotechnology, 107, 505-574.

[11]   Sakaki, T., Shibata, M., Miki, T., Hirosue, H. and Hayashi, N. (1996) Decomposition of Cellulose in Near-Critical Water and Fermentability of the Products. Energy & Fuels, 10, 684-688.

[12]   Yang, B., Dai, Z.Y., Ding, S.Y. and Wyman, C.E. (2011) Enzymatic Hydrolysis of Cellulosic Biomass. Biofuels, 2, 421-450.

[13]   Horn, S.J., Vaaje-Kolsad, G., Westereng, B. and Eijsink, V.G.H. (2012) Novel Enzymes for the Degradation of Cellulose. Biotechnology for Biofuels, 5, 45.

[14]   Lalaurette, E., Thammannagowda, S., Mohagheghi, A., Maness, P.C. and Logan, B.E. (2009) Hydrogen Production from Cellulose in a Two-Stage Process Combining Fermentation and Electrohydrogenesis. International Journal of Hydrogen Energy, 34, 6201-6210.

[15]   Putra, A.E.E., Nomura, S., Mukasa, S. and Toyota, H. (2012) Hydrogen Production by Radio Frequency Plasma Stimulation in Methane Hydrate at Atmospheric Pressure. International Journal of Hydrogen Energy, 37, 16000-16005.

[16]   Abbas, F.H. and Wan Daud, W.M.A. (2010) Hydrogen Production by Methane Decomposition: A Review. International Journal of Hydrogen Energy, 35, 1160-1190.

[17]   Tozzini, V. and Pellegrini, V. (2013) Prospects for Hydrogen Storage in Graphene. Physical Chemistry Chemical Physics, 15, 80-89.

[18]   Ma, T., Isobe, S., Morita, E., Wang, Y., Hashimoto, N., Ohnuki, S., Kimura, T., Ichikawa, T. and Kojima, Y. (2011) Correlation between Kinetics and Chemical Bonding State of Catalyst Surface in Catalyzed Magnesium Hydride. International Journal of Hydrogen Energy, 36, 12319-12323.

[19]   Heberlein, J. and Murphy, A.B. (2008) Thermal Plasma Waste Treatment. Journal physics D, 41, Article ID: 053001.

[20]   Choi, S., Park, D.W. and Watanabe, T. (2012) Thermal Plasma Decomposition of Fluorinated Greenhouse Gases. Nuclear Engineering and Technology, 44, 21-32.

[21]   Sakano, M., Tanaka, M. and Watanabe, T. (2001) Application of Radio-Frequency Thermal Plasmas to Treatment of Fly Ash. Thin Solid Films, 386, 189-194.

[22]   Nomura, S., Mukasa, S., Toyota, H., Miyake, H., Yamashita, H. and Maehara, T. (2011) Characteristics of In-Liquid Plasma in Water under Higher Pressure Than Atmospheric Pressure. Plasma Sources Science and Technology, 20, Article ID: 034012.

[23]   Maehara, T., Miyamoto, I., Kurokawa, K., Hashimoto, Y., Iwamae, A., Kuramoto, M., Yamashita, H., Mukasa, S., Toyota, H., Nomura, S. and Kwashima, A. (2008) Degradation of Methylene Blue by RF plasma in Water. Plasma Chemistry and Plasma Processing, 28, 467-482.

[24]   Nomura, S., Toyota, H., Mukasa, S., Yamashita, H., Maehara, T. and Kawashima, A. (2009) Production of Hydrogen in a Conventional Microwave Oven. Journal of Applied Physics, 106, Article ID: 073306.

[25]   Kurihara, H. and Yajima, T. (2007) Decomposition of Toluene by Liquid-phase Atmospheric-Pressure Microwave Plasma Generated Using Carbon Felt Pieces Impregnated with NaCl. Chemistry Letters, 36, 870-871.

[26]   Hattori, Y., Mukasa, S., Nomura, S. and Toyota, H. (2010) Optimization and Analysis of Shape of Coaxial Electrode for Microwave Plasma in Water. Journal of Applied Physics, 107, Article ID: 063305.

[27]   Hattori, Y., Mukasa, S., Toyota, H. and Nomura, S. (2013) Electrical Breakdown of Microwave Plasma in Water. Current Applied Physics, 13, 1050-1054.

[28]   Nomura, S., Putra, A.E.E., Mukasa, S., Yamashita, H. and Toyota, H. (2011) Plasma Decomposition of Clathrate Hydrates by 2.45GHz Microwave Irradiation at Atmospheric Pressure. Applied Physics Express, 4, Article ID: 066201.

[29]   Mukasa, S., Nomura, S., Toyota, H., Maehara, T., Abe, F. and Kawashima, A. (2009) Temperature Distributions of Radio-Frequency Plasma in Water by Spectroscopic Analysis. Journal of Applied Physics, 106, Article ID: 113302.

[30]   Mukasa, S., Nomura, S., Toyota, H., Maehara, T. and Yamashita, H. (2011) Internal Conditions of a Bubble Containing Radio-Frequency Plasma in Water. Plasma Sources Science and Technology, 20, Article ID: 034020.

[31]   Yang, Y., Cho, Y.I. and Fridman, A. (2012) Plasma Discharge in Liquid: Water Treatment and Applications. CRC Press, Boca Raton, 102.

[32]   Sato, M. (2009) Degradation of Organic Contaminants in Water by Plasma. International Journal of Plasma Environmental Science and Technology, 3, 8-14.

[33]   Maehara, T., Nishiyama, K., Onishi, S., Mukasa, S., Toyota, H., Kuramoto, M., Nomura, S. and Kawashima, A. (2010) Degradation of Methylene Blue by Radio Frequency Plasmas in Water under Ultraviolet Irradiation. Journal of Hazardous Materials, 74, 473-476.