FNS  Vol.6 No.10 , July 2015
Assessment of Gross Chemical Composition, Mineral Composition, Vitamin Composition and Amino Acids Composition of Wheat Biscuits and Wheat Germ Fortified Biscuits
Abstract: Wheat germ is reckoned valuable healthful functional food. The present investigation was performed to assess nutritional status of wheat biscuits and wheat germ fortified biscuits. Study included determination of gross chemical composition, caloric value, minerals (Mn, Ca, Fe, Cu, P, Na and K), vitamins (C, Folic acid, A, and E), and amino acid composition of wheat biscuits and 15%, 20% wheat germ fortified biscuits. Likewise physical and sensory characteristics of studied biscuits were assessed. The data revealed that 20% wheat germ fortified biscuits proved to be nutritious functional healthful food. It improved both physical, sensory characteristics and recorded the highest crude protein (12.20%), crude fiber (2%), and the least fat (9.63%), moisture (3.01%), and caloric value (436.31 Kcal/100g). While it recorded the highest Mn and Cu contents as well as increased vitamins C, Folic acid, A, and E. Besides, 20% wheat germ fortified biscuits increased all the eight essential amino acids contents resulting in an improvement of the nutritive value of wheat biscuits. Therefore it could be recommended for caloric reduced diets for obese and overweight persons. Likewise, it should be increasing interest as an ingredient in the industry as functional and healthy foods formulations as biscuits, bread and cakes.
Cite this paper: Youssef, H. (2015) Assessment of Gross Chemical Composition, Mineral Composition, Vitamin Composition and Amino Acids Composition of Wheat Biscuits and Wheat Germ Fortified Biscuits. Food and Nutrition Sciences, 6, 845-853. doi: 10.4236/fns.2015.610088.

[1]   Sjovall, O., Virtalaine, T., Lapvetelainen, A.M. and Kallio, H. (2000) Development of Rancidity in Wheat Germ Analyzed by Headspace Gas Chromatography and Sensory Analysis. Journal of Agricultural and Food Chemistry, 48, 3522-3527.

[2]   Sidhu, J.S., Al-Hooti, S.N., Al-Sager, J.M. and Al-Othman, A. (2001) Studies on the Development of Pan Bread Using Raw Wheat Germ. Journal of Food Quality, 24, 235-247.

[3]   Arrigoni, E., Jorger, F., Kolloffelm, B., Roulet, I., Herensperger, M., Meile, L. and Amado, R. (2002) In Vitro Fermentability of a Commercial Wheat Germ Preparation and Its Impact on the Growth of Bifidobacteria. Food Research International, 35, 475-481.

[4]   Hessen, K.R.F. (2003) Chemistry of Cereals and Cereals Products. Dar El-Kotob for Publication and Distribution. Cairo (In Arabic).

[5]   El-Manfaloty, M.M.H.M.L. (2010) Nutritional and Biological Assessment of Wheat Germ and Its Effect on Immune System in the Experimental Rats. Ph.D. Thesis, Faculty of Specific Education, Ain Shams University, Cairo.

[6]   Bilgicli, N., Elgun, A., Herken, E.N., Turker, S., Ertas, N. and Ibanoglu, S. (2006) Effect of Wheat Germ and Wheat Bran on the Chemical, Nutritional and Sensory Quality of Tarhana, a Fermented Wheat Flour-Yoghurt Product. Journal of Food Engineering, 77, 680-686.

[7]   Bilgicli, N. and Ibanoglu, S. (2007) Effect of Wheat Germ and Wheat Bran on the Fermentation Activity, Phytic Acid Content and Color of Terhana, a Wheat Flour-Yoghurt Mixture. Journal of Food Engineering, 78, 681-686.

[8]   Brandolini, A. and Hidalgo, A. (2012) Wheat Germ: Not Only a By-Product. International Journal of Food Sciences and Nutrition, 63, 71-74.

[9]   Sudha, M.L., Srivastava, A.K. and Leelavathi, K. (2007) Studies on Pasting and Structural Characteristics of Thermally Treated Wheat Germ. European Food Research and Technology, 225, 351-357.

[10]   Muehlthaeuser, H. (2003) Grain Germs for Bread and Other Baked Goods. Getreidekeimlinge für Brot und Backwaren. In: Getreide, Mehl und Brot, 57, 28-30, 35-39.

[11]   Marshall, P.A., Vandepeer, J.M., Pant, I., Trenerry, V.C., Scheelings, P. and Buick, D.R. (1997) The Development and Evaluation of Secondary Food Reference Materials for the Determination of Cholesterol, Fatty Acids and Selected Water-Soluble Vitamins in Foods. Food Chemistry, 58, 269-276.

[12]   Onstand, D. (1996) Whole Foods Companion: A Guide for Adventurous Cooks, Curious Stoppers and Lovers of Natural Foods. Chelsea Green Publishing Company, White River Junction.

[13]   Wood, J. (1999) The New Whole Food Encyclopedia. Penguin Books, New York.

[14]   Zhu, K., Zhou, K.H., and Qian, H.F. (2006) Protein Extracted from Defatted Wheat Germ: Nutritional and Structural Properties. Cereal Chemistry, 83, 69-75.

[15]   Arshad, M.U., Anjum, F.M. and Zahoor, T. (2007) Nutritional Assessment of Cookies Supplemented with Defatted Wheat Germ. Food Chemistry, 102, 123-128.

[16]   Semenyuk, V.F. and Dyakonova, A.K. (1986) Chemical Composition of Wheat Germ. Pishchevaya i Pereabatyvayushchaya Promyshlennost, No. 5, 37.

[17]   Wennermark, B. and Jaegerstand, M. (1992) Breadmaking and Storage of Various Wheat Fractions Affect Vitamin E. Journal of Food Science, 57, 1205-1209.

[18]   Sidhu, J.S., Al-Hooti, S.N. and Al-Sager, J.M. (1998) Effect of Adding Wheat Bran and Germ Fractions on the Chemical Composition of High Fiber Toast Bread. Food Chemistry, 67, 365-371.

[19]   Abu-Elmatti, S., Abd-El-Hady, M.M., El-Sahi, K.M. and El-Badawi, A.A. (2000) Enrichment of Two Types of Biscuits by Wheat Germ. Egyptian Journal of Food Science, 24, 331-344.

[20]   Bouchard, C., Gausseres, N., Jimenez, L., Attal, F., Bonnot, I., Notardonato, L. and Rocher, P. (2003) Biscuit Product Permitting Nutritional Prevention of Oxidative Stress. French Patent Application.

[21]   Constandache, M. (2007) The Influence of Fortification of Bread with Exogenous Proteins on the Protein Digest Ability. Journal of Agroalminentary Processes and Technologies, 13, 461-466.

[22]   Constandache, M., Radu, S. and Condrea, E. (2008) The Influence of Bread Fortification with Wheat Germs on Bread Quality and Proteic Value. Journal of Agroalimentary Processes and Technologies, 14, 227-231.

[23]   Gomez, M., Gonzalez, J. and Oliete, B. (2012) Effect of Extruded Wheat Germ on Dough Rheology and Bread Quality. Food and Bioprocess Technology, 5, 2409-2418.

[24]   Bilgicli, N. and Levent, H. (2013) Improvement of Nutritional Properties of Cake with Wheat Germ and Resistant Starch. Journal of Food and Nutrition Research, 52, 210-218.

[25]   Levent, H. and Bilgicli, N. (2013) Quality Evaluation of Wheat Germ Cake Prepared with Different Emulsifiers. Journal of Food Quality, 36, 334-341.

[26]   Youssef, M.K.E. (2015) Wheat Germ is a Nutritional Treasure Important in Our Life. Environmental Bulletin, No. 7, January 2015, 17-18. Faculty of Agriculture, Assiut University, Assiut, Egypt. (In Arabic)

[27]   Youssef, M.K.E. (2015) Wheat Germ Healthful Protective Functional Food. Assiut Journal of Environmental Studies, No. 41, January 2015, 75-83. Assiut Center of Environmental Studies and Research, Assiut University, Assiut, Egypt. (In Arabic)

[28]   Rao, H. and Manohar, S. (1999) Effects of Emulsifier Fat Level and Type on the Rheological Characteristics of Biscuit Dough and Quality of Biscuit. Journal of the Science of Food and Agriculture, 79, 1223-1231.<1223::AID-JSFA346>3.0.CO;2-W

[29]   Saba, N.H. (1997) Culinary is Science and Art. P. 685. Dar El-Maaref, Cairo. (In Arabic)

[30]   Vatsala, C.N. and Hardias Rao, P. (1991) Studies on Invert Sugar for Use in Biscuits. Journal of Food Science and Technology, 28, 149-152.

[31]   Manohar, R.S. and Rao, P.H. (1997) Effect of Mixing Period and Additives on the Rheological Characteristics of Dough and Quality of Biscuits. Journal of Cereal Science, 25, 197-206.

[32]   Larmond, E. (1977) Laboratory Methods of Sensory Evaluation of Food. Canadian Government Publishing Center, Ottawa.

[33]   AOAC (2010) Official Methods of Analysis of Association of Official Analytical Chemists. 18th Edition, Washington, DC.

[34]   Seleet, R. (2010) The Analysis of Nutrients in Foods. Academic Press. Inc., London.

[35]   Isaac, R.A. and Johnson, W.A. (2002) Elemental Analysis of Plant Tissue by Plasma Emission Spectroscopy. Collaborative Study. Journal of the Association of Official Analytical Chemists, 68, 499-505.

[36]   AOAC (2005) Official Methods of Analysis of Association of Official Analytical Chemists. 18th Edition, Washington, DC.

[37]   AOAC (2012) Official Methods of Analysis of Association of Official Analytical Chemists. 19th Edition, Washington, DC.

[38]   Ordriozola-Serrano, I., Hernandez, T. and Bellso, O.M. (2007) Comparative Evaluation of UV-HPLC Methods and Reducing Agents to Determine Vitamin C in Fruits. Food Chemistry, 105, 1151-1158.

[39]   Albala-Hurtado, S., Veciana-Nugues, M.T., Izquierdo-Pulido, M. and Marine-Font, A. (1997) Determination of Water-Soluble Vitamins in Infant Milk by High-Performance Liquid Chromatography. Journal of Chromatography A, 778, 247-253.

[40]   Gomis, D.B., Fernadert, M.P. and Gutiérrez Alvarez, M.D. (2000) Simultaneous Determination of Fat-Soluble Vitamins and Provitamins in Milk by Microcolumn Liquid Chromatography. Journal of Chromatography A, 891, 109-114.

[41]   Baxter, J.H. (1996) Amino Acids. In: Nollet, L.M.L., Ed., Handbook of Food Analysis, Vol. I, Marcel Dekker. Inc., New York, 179-228.

[42]   Sastry, C. and Tummuru, M. (1995) Spectrophotometric Determination of Tryptophan in Protein. Journal of Food Science and Technology, 22, 146-147.

[43]   Wu, S.P. (2009) A Study on Technology and Quality of Steamed Bread Made of Wheat Germ. Cereal and Feed Industry, No. 3, 27-29.

[44]   Steele, R.J. (1981) The Mineral Content of Some Australian Wheat Germ, Bran and Bran-Based Foods. Food Technology in Australia, 33, 412-414.

[45]   Szira, F., Monostori, I., Galiba, G., Rakszegi, M. and Balint, A.F. (2014) Micronutrient Contents and Nutrional Wheat Varieties—A Survey in Hungary. Cereal Research Communications, 42, 293-302.

[46]   Zia-UI-Haq. M., Riaz, M., DeFeo, V., Jaafar, H.Z.E. and Moga, M. (2014) Rubus fruticosus L.: Constituents, Biological Activities and Health Related Uses. Molecules, 19, 10998-11029.

[47]   Zia-UI-Haq, M., Ahmad, S., Imran, I., Ercisli, S. and Moga, M. (2015) Nutritional Quality of Food Depends Directly on the Quantity and Composition of the Minerals It Contains.

[48]   Zia-Ul-Haq, M., Ahmad, S., Imran, I., Ercisli, S. and Moga, M. (2015) Compositional Studies of Grewia asiatica L. Seeds Grown in Pakistan. Comptes rendus de l’Académie bulgare des Sciences, 68, 191-200.

[49]   Engelsen, M.M. and Hunsen, A. (2009) Tocopherol and Tocotrienol Content in Commercial Wheat Mill Streams. Cereal Chemistry, 86, 499-502.

[50]   Hassanun, M.M.M., Abdel-Razek, A.G., Rudzinska, M. Siger, A., Ratusz, K. and Przybylski, R. (2014) Phytochemcial Contents and Oxidative Stability of Oils from Non-Traditional Sources. European Journal of Lipid Science and Technology, 116, 1563-1571.

[51]   Knowles, J., Watkinson, C. and Johnstone, I. (2014) Extraction of Wheat Germ: The Production of Wheat Germ Oil and Defatted Stabilized Wheat Germ. Lipid Technology, 26, 157-161.

[52]   Baldini, V.L.S., Laderoza, M., Draetta, I. and Dos, S. (1982) Chemical and Biochemical Characterization of Wheat Germ and Maize Germ. Coletanea do Instituto de Techologia de Alimentos, 12, 1-14.

[53]   Ke-Xue, Z., Hui-Ming, Z. and Hai-Feng, Q. (2006) Comparative Study of Chemical Composition and Physico-Chemical Properties of Defatted Wheat Germ Flour and Its Protein Isolate. Journal of Food Biochemistry, 30, 321-341.

[54]   Umair, A., Muhammad, A. and Tahir, Z. (2007) Nutritional Assessment of Cookies Supplemented with Defatted Wheat Germ. Food Chemistry, 102, 124-128.