JST  Vol.4 No.3 , September 2014
Temperature Effects on Gas Sensing Properties of Electrodeposited Chlorine Doped and Undoped n-Type Cuprous Oxide Thin Films
ABSTRACT
As one of the most widely used domestic fuels, the detection of possible leakages of Liquefied Petroleum (LP) gas from production plants, from cylinders during their storage, transport and usage is of utmost importance. This article discusses a study of the response of undoped and chlorine doped electrodeposited n-type Cuprous Oxide (Cu2O) films to of LP gas. Undoped n-type Cu2O films were fabricated in an electrolyte bath containing a solution of sodium acetate and cupric acetate whereas n-type chlorine doped Cu2O thin films were prepared by adding a 0.02 M cuprous chloride (CuCl2) into an electrolyte solution containing lactic acid, cupric sulfate and sodium hydroxide. The n-type conductivity of the deposited films was determined using spectral response measurements. The structural and morphological properties of the fabricated films were monitored using X-ray diffraction (XRD) and Scanning Electron Microscopy (SEM). Due to doping, the overall conductivity of the chlorine doped n-type Cu2O films increased by several orders of magnitude. The temperature dependent gas responses of both the undoped and chlorine doped n-type Cu2O thin films to the LP gas was monitored by measuring the electrical resistance (R), and using the contact probe method at a constant gas flow rate of 0.005 ml/s. Upon exposure to gases, both doped and undoped films showed a good response to the gas by increasing/decreasing the electrical resistance by ΔR. The undoped n-type Cu2O thin films showed a negative response (ΔR < 0) at all temperatures resulting in a maximum response around 85&#176C. However, the chlorine doped n-type Cu2O thin films initially showed a positive response (ΔR > 0) to the LP gas which then reversed its sign to give a negative response which peaked at 52°C. The positive response shown by the chlorine doped Cu2O films vanished completely at 42°C.

Cite this paper
Bandara, N. , Jayathilaka, C. , Dissanayaka, D. and Jayanetti, S. (2014) Temperature Effects on Gas Sensing Properties of Electrodeposited Chlorine Doped and Undoped n-Type Cuprous Oxide Thin Films. Journal of Sensor Technology, 4, 119-126. doi: 10.4236/jst.2014.43011.
References
[1]   Seiyama, T., Kato, A., Fujiishi, K. and Nagatani, M. (1962) A New Detector for Gaseous Components Using Semiconductive Thin Films. Analytical Chemistry, 34, 1502-1503.
http://dx.doi.org/10.1021/ac60191a001

[2]   Parmar, M. and Rajanna, K. (2011) Copper (II) Oxide Thin Film for Methanol and Ethanol Sensing. International Journal on Smart Sensing and Intelligent Systems, 4, 710-725.

[3]   Yamazoe, N., Sakai, G. and Shimanoe, K. (2003) Oxide Semiconductor Gas Sensors. Catalysis Surveys from Asia, 7, 63-73.
http://dx.doi.org/10.1023/A:1023436725457

[4]   Ahalapitiya, H.J., Samarasekara, P. and Kun, G. (2009) Methane Gas Sensors Application of Cuprous Oxide Synthesized by Thermal Oxidation. Physica Status Solidi (a), 206, 332-337.
http://dx.doi.org/10.1002/pssa.200824126

[5]   Shishiyanu, T.S. and Lupan, O.I. (2006) Novel NO2 Gas Sensor Based on Cu2O Thin Films. Sensors and Actuators B: Chemical, 113, 468-476.
http://dx.doi.org/10.1016/j.snb.2005.03.061

[6]   Dhawle, D.S., et al. (2009) Liqueified Petoleum Gas (LPG) Sensing Perfomance of Electron Beam Irradiated Chemically Deposited Ti2O Thin Film. Sensors and Actuators B: Chemical, 141, 58-64.
http://dx.doi.org/10.1016/j.snb.2009.06.025

[7]   Shukla, T. (2012) Synthesis of Tin Oxide Thick Film and Its Investigation as a LPG Sensor at Room Temperature. Journal of Sensor Technology, 2, 102-108.
http://dx.doi.org/10.4236/jst.2012.23015

[8]   Siripala, W. and Kumara, K.P. (1989) A Photo Electrochemical Investigation of n- and p-Type Semiconducting Behavior of Copper Oxide Films. Semiconductor Science and Technology, 4, 465.
http://dx.doi.org/10.1088/0268-1242/4/6/007

[9]   Jayathilaka, K.M.D.C., Siripala, W. and Jayanetti, J.K.D.S. (2013) Efficiency Improvement of Cuprous Oxide Based Cl Doping. Proceedings of the International Conference (Solar Asia), Kuala Lumpur, 91-96.

[10]   Bandara, K.N.D., Jayathilaka, K.M.D.C., Siripala, W. and Jayanetti, J.K.D.S. (2012) Electrodeposited Nano Crystalline Cu2O Thin Films for Gas Sensing Applications. Proceedings of the 68th Technical Sessions, Sri Lanka Association for the Advancement of Science (SLAAS), 56.

[11]   Han, X.F. (2011) Electrochemical n-Type Doping in Metal Oxides and Its Application in Photovoltaic. Ph.D. Thesis, University of Texas at Arlington, Arlington, 32-33.

 
 
Top