ENG  Vol.2 No.12 , December 2010
The Influence of Microscopic Fungi on Chromated Galvanized Zinc Coatings
Abstract: A solution containing Cr(VI), Cr(NO3)3 and its complex with an organic acid as well as several commercial solutions containing Cr(III) complexes with an organic acid and additionally CO2+, F-, SO42- ions were used for the studies. Results of the studies obtained in the following commercial solutions: Likonda 2AT, Cr(NO3)3 + malonic acid; Likonda 3Cr5 and Likonda 3CrMC are discussed. Steel coated with chromated Zn coatings was contaminated by some microscopic fungi. The variety of fungi on chromated plates diminished, however the propagules of fungi did not disappear completely. The Likonda 3Cr5 solution diminishes fungi contamination on chromated steel most effectively. In water used to rinse the surface of chromated plates the number of fungi propagules was detected to be higher as compared to that on the plate surface. The least quantity of fungi propagules was detected in water used to rinse plates coated in the Likonda 3Cr5 solution. The main part of fungi detected on chromated plates treated in the Likonda 3Cr5 solution were the fungi of Cladosporium species (C.herbarum, C.cladosporioides). The latter species also dominated on chromated plates coated with zinc and treated with the other solution. It should be mentioned, that on these plates chromated in this solution, Actinomycetes of the Streptomyces group were abundant. After comparison of surfaces of the plates treated in four solutions it has been determined that the surface of the plates treated in the Likonda 3Cr5 passivation solution and exposed to modelling conditions changed least of all. It has been noticed that on the subject studied white porous rust accumulates, the intensity of this process on the surface studied determines both the probability of corrosion and the resistance of the used safety means to the external factors.
Cite this paper: nullA. Lugauskas, I. Prosyčevas, A. Selskienė, I. Demčenko, A. Narkevičius, D. Bučinskienė and E. Binkauskienė, "The Influence of Microscopic Fungi on Chromated Galvanized Zinc Coatings," Engineering, Vol. 2 No. 12, 2010, pp. 979-997. doi: 10.4236/eng.2010.212125.

[1]   C. R. Tomachuk and O. B. Ferraz, “Investigation by EIS of Trivalent Chromate Conversion Coating on Galvanized Steel,” 16th International Corrosion Congress, Bejing, 22 September 2005, pp. 19-24.

[2]   F. J. Chen, N.-T. Wen, M.-D. Ger, Y. N. Pan and C.-S. Lin, “Characterization of Hexavalent and Trivalent Chromium Conversion Coatings on Electrogalvanized Steel,” The 213 Electrochemical Society Meeting, Phoenix, 18-22 May 2008.

[3]   M. Kending and R. G. Buchheit, “Corrosion Inhibition of Aluminium and Aluminium Alloys by Soluble Chromates, Chromate Coatings and Chromate-Free Coatings,” Corrosion, Vol. 59, No. 5, 2003, pp. 379-400.

[4]   X. Zhang, C. van den Bos, W. G. Sloof, A. Hovestad, H. Terryn and J. H. W. de Wit, “Comparison of the Mor- phology and Corrosion Perfomance of Cr(VI) and Cr(III) Based Conversion Coatings on Zinc,” Surface & Coatings Technology, Vol. 199, No. 1, 2005, pp. 92-104.

[5]   H. Asqari, M. R. Toroghejod and M. A. Golozaz, “On Texture, Corrosion Resistance and Morphology of Hot-Dip Galvanized Zinc Coatings,” Applied Surface Science, Vol. 253, No. 16, 2007, pp. 6719-6777.

[6]   V. R?zait?, M. Samulevi?ien?, I. Dem?enko, V. Dikinis and R. ?armaitis, “Kai Kuri? Organini? Med?iag? Inhibicinis Poveikis Plieno Korozijai Neorganini? RūG??i?, J? Mi?ini? Ir Cr(III) Pasyvacijos RūG-??iuosiuose Tir- paluose / Inhibition of Corrosion of Steel in Solutions of Some Inorganic Acids Their Mixtures and Acidic Solution of Cr(III) Passivation of Zn,” Chemin? Technologija, in Lithuanian, Vol. 51, No. 2, 2009, pp. 59-69.

[7]   S. Katz and H. Salem, “The Biological and Environmental Chemistry of chromium,” VCH Publishers, New York, 1994.

[8]   N.-T. Wen, C.-S. Lin, C.-Y. Bai and M.-D. Ger, “Structures and Characteristics of Cr(III)-Based Conversion Coatings on Elektrogalvanized Steels,” Surface and Coatings Technology, Vol. 203, No. 3-4, 2008, pp. 317-323.

[9]   S. S. Abd El Rehim, M. A. M. Ibrahim and M. M. Dankeria, “Thin Films of Chromium Electrodeposition from Trivalent Chromium Electrolyte,” Transaction of the Institute of Metal Finishing(UK), Vol. 80, No. 1, 2002, pp. 29-33.

[10]   R. Cook, J. Elliott and S. Sapp, “Electrochemical and Computational Screening of Non-Toxic Organic Replacements for Hexavalent Chromate Corrosion Inhibitors,” Tri-service Corrosion Conference (Army?Navy?Air Force?Starines?Coost Guard?Nasa), Denver, 3-7 December 2007, pp. 1-5.

[11]   V. Dikinis, V. R?zait?, I. Dem?enko, A. Selskis, T. Bernatavi?ius and R. ?armaitis, “Regularities of Zinc Corrosion and Formation of Conversion Films on the Zinc Surface in Acidic Solution of Cr(III) Compounds,” Transactions of the Institute of Metal Finishing, Vol. 82, No. 4, 2004, pp. 1-7.

[12]   V. Dikinis, V. R?zait?, J. Vai?iūnien?, A. Sudavi?ius, I. Dem?enko and R.?armaitis, “Gele?ies Ir Cinko Korozija Kai Kuri? Neorganini? Ir Organini? Rugs?i? Tir- paluose/Corrosion of Iron and Zinc in Solution of Inorganic and Organic Acids,” Chemin? Technologija, Vol. 1, No. 47, 2008, pp. 13-16.

[13]   V. Dikinis, V. R?zait?, J. Vai?iūnien?, A. Sudavi?ius, I. Dem?enko and R.?armaitis, “Cr3+ Ir Co2+ Jon? ?taka Gele?ies Ir Cinko Korozijai Kai Kuri? Neorganini? Ir Oraganini? Rūgs?i? Tirpaluose / Influence of Cr3+ and Co2+ ions and Zinc Corrosion in Solution of Some Inorganic and Organic Acids,” Chemin? Technologija, Vol. 2, No. 48, 2008, pp. 15-29.

[14]   Pérez Néstor, “Electrochemistry and Corrosion Science,” Springer, Massachusetts, 2004.

[15]   K. H. Cheung and J. D. Gu, “Mechanizm of Hexavalent Chromium Detoxification by Microorganism and Bioremedation Application Potential: A Review,” International Biodeterioration & Biodegradation, Vol. 59, No. 1, 2007, pp. 8-15.

[16]   D. Park, Y. S. Yun and J. M. Park, “Use of Dead Fungal Biomass for the Detoxification of Hexavalent Chromium: Screening and Kinetics,” Process Biochemistry, Vol. 40, No. 7, 2008, pp. 2559-2565.

[17]   A. Lugauskas, D. Pe?iulyt?, R. Ramanauskas, D. Bu- ?inskien?, A. Narkevi?ius and V. Ulevi?ius, “Mikro- micetai Metal? Korozijos Procesuose Atmosferos S?ly- gomis,” Ekologija, in Lithuanian, Nr. 1, 2005, pp. 11-26.

[18]   A. Lugauskas, K. Leinartas, A. Grigucevi?ien?, A. Selskien? and E. Binkauskien?, “Possibility of Microm- ycetes Detected in Dust to Grow on Metal (AL,Fe,Cu,Zn) and Polyaniline-Modified Ni,” Ecology, Vol. 54, No. 3, 2008, pp. 149-157.

[19]   H. A. Videla and L. K. Herrera, “Microbiologi-cally Influenced Corrosion: Looking to the Future,” Interna-tional Microbiology, Vol. 8, No. 3, 2005, pp. 169-180.

[20]   H. A. Videla and L. K. Herrera, “Understanding Microbial Inhibi-tion of Corrosion. A Comprehensive Overview,” International Biodeterioiration & Biodegradation, Vol. 63, No. 7, 2009, pp. 896-900.

[21]   B. Poljsak, I. Pocsi, P. Raspor and M. Pesti, “Interference of Chromium with Biological Systems in Yeasts and Fungi: A Review,” Journal of Basic Microbiology, Vol. 50, No. 1, 2010, pp. 21-36.

[22]   M. A. Dominguez-Crespo, E. Onofre-Bustamante, A. M. Torres-Huerta and F. J. Rodriguez Gomez, “Morphology and Corrosion Performance of Chromate Conversion Coatings on Different Substrates,”Journal of the Mexican Chemical Society, Vol. 52, No. 4, 2008, pp. 235-240.

[23]   S. Maruthamuthu, N. Muthukumar, M. Natesan and N. Palaniswamy, “Role of Air Microbes on Atmospheric Corrosion,” Current Science, Vol. 94, No. 3, 2008, pp. 359-363.

[24]   I. Beech, A. Bergel, A. Mollica, H.-C. Flem-ming(Leader), V. Scotto and W. Sand, “Simple Methods for the Investigation of the Role of Biofilms in Corrosion,” Brite Euram Thematic Network on Mic of Industrial Materials, Biofilm Publication, 2000, pp. 1-27.

[25]   M. V. da Costa, C. T. Oliveira, T. L. Menezes, I. L. Muller and C. F. Malfatti, “Electrochemical Study of Silane Films and Chromate Conversion Coatings Applied on Zinc Coatings,” 11th International Coference on Advanced Materials, Brasil, 20-25 September 2009, pp. 20-25.

[26]   M. Pesti, Z. Gazdag and J. Belagyi, “In Vivo Inte-raction of Trivalent Chromium with Yeast Plasma Membrane, as Revealed by EPR Spectroscopy,” FEMS Microbiology Letters, Vol. 182, No. 2, 2000, pp. 375-380.

[27]   G. Gunasekaran, S. Chongdar, S. N. Gaonkar and P. Kumar, “Influence of Bacteria on Film Formation Inhibiting Corrosion,” Corrosion Science, Vol. 46, No. 8, 2004, pp. 1953-1967.

[28]   T. Fukuda, Y. Ishino, A. Ogawa, K. Tsutsumi and H. Morita, “Cr(VI) Re-duction from Contaminated Soils by Aspergllus sp N2 and Penicillium sp N3 Isolated from Chromium Deposits,” Journal of General and Applied Microbiology, Vol. 54, No. 5, 2008, pp. 295-303.

[29]   G. Wang, L. Huang and Y. Zhang, “Cathodic Reduction of Hexavalent Chromium [Cr(VI)] Coupled with Electricity Generation in Microbial Fuel Cells,” Biotechnology Letters, Vol. 30, No.11, 2008, pp. 1959-1966.

[30]   D. G. Zvyagintsev, “Methods of Soil Microbiology and Biochemi-stry,” Publishing house of Moscow University, Moscow, 1991.

[31]   V. Moho?ek-Gro?ev, R. Bo?a? and G. J. Puppels, “Vi- brational Spectroscopic Characterization of Wild Growing Mushrooms and Toadstools,” Spectrochimica Acta, Vol. 57, No.14, 2001, pp. 2815-2829.