JWARP  Vol.5 No.7 A , July 2013
A Study on Zeolite Performance in Waste Treating Ponds for Treatment of Palm Oil Mill Effluent
ABSTRACT

Oil palm currently occupies the largest acreage of farm land in Malaysia. In 2011, the production of palm oil in Malaysia was recorded as 19.8 million tons which has led to a huge amount of wastewater known as palm oil mill effluent (POME). This work focuses on the ponding system which acts as wastewater treatment plant in order to treat POME. The conventional ponding system applied in mills consists of a series of seven ponds. The maintenance costs of the pond are expensive thus study of alternative methods is needed. POME treatment using zeolite shows a potential to overcome the problem. Samples collected from selected ponds are tested and analyzed using water analyzer method. Result from adsorption by zeolite shows a significant reduction of COD, BOD, Fe, Zn, Mn and turbidity. This shows that zeolite is highly potential to be applied as adsorbent in the POME treatment plants. The results here may lead to lower maintenance cost, lower quantity of treatment ponds and lesser land occupied for the treatment of POME in Malaysia.


Cite this paper
M. Ismail, S. Dalang, S. Syam and S. Izhar, "A Study on Zeolite Performance in Waste Treating Ponds for Treatment of Palm Oil Mill Effluent," Journal of Water Resource and Protection, Vol. 5 No. 7, 2013, pp. 18-27. doi: 10.4236/jwarp.2013.57A004.
References
[1]   S. Arifand and T. A. Tengku Mohd Ariff, “The Case Study on the Malaysian Palm Oil,” United Nations Conference on Trade and Development/Economic and Social Commission for Asia and the Pacific Regional Workshop on Commodity Export Diversification and Poverty Reduction in South and South-East Asia, Bangkok, 3-5 April 2001.

[2]   G. D. Najafpour, A. A. LZinatizadeh, A. R. Mohamed, M. Hasnain Isa, H. Nasrollahzadeh, “High-Rate Anaerobic Digestion of Palm Oil Mill Effluent in an Upflow Anaerobic Sludge-Fixed Film Bioreactor,” Process Biochemistry, Vol. 41, No. 2, 2006, pp. 370-379. doi:10.1016/j.procbio.2005.06.031

[3]   R. Borja, C. J. Banks and E. Sánchez, “Anaerobic Treatment of Palm Oil Mill Effluent in a Two-Stage Up-Flow Anaerobic Sludge Blanket (UASB) Reactor,” Journal of Biotechnology, Vol. 45, No. 2, 1996, pp. 125-135. doi:10.1016/0168-1656(95)00154-9

[4]   S. Yacob, M. A. Hassan, Y. Shirai, M. Wakisaka and S. Subash, “Baseline Study of Methane Emission from Open Digesting Tanks of Palm Oil Mill Effluent Treatment,” Chemosphere, Vol. 59, No. 11, 2005, pp. 1575-1581. doi:10.1016/j.chemosphere.2004.11.040

[5]   C. O. Onyia, A. M. Uyub, J. C. Akunna, N. A. Norulaini and A. K. M. Omar, “Increasing the Fertilizer Value of Palm Oil Mill Sludge: Bioaugmentation in Nitrification. Sludge Management Entering the Third Millenium,” Industrial, Combined, Water and Wastewater Residues, Vol. 44, 2001, pp. 157-162.

[6]   K. K. Chin, S. W. Lee and H. H. Mohammad, “A Study of Palm Oil Mill Effluent Treatment Using a Pond System,” Water Science and Technology, Vol. 34, No. 1, 1996, pp. 119-123. doi:10.1016/S0273-1223(96)00828-1

[7]   A. W. Chester and E. G. Derouane, “Zeolite Characterization and Catalysis,” Springer, Heidelberg, London, New York, 2001.

[8]   D. Mohan and K. P. Singh, “Single- and Multi-Component Adsorption of Cadmium and Zinc Using Activated Carbon Derived from Bagasse—An Agricultural Waste,” Water Research, Vol. 36, No. 9, pp. 2304-2318. doi:10.1016/S0043-1354(01)00447-X

[9]   V. J. Inglezakis, M. D. Loizidou and H. P. Grigoropoulou, “Ion Exchange of Pb2+, Cu2+, Fe3+, and Cr3+ on Natural Clinoptilolite: Selectivity Determination and Influence of Acidity on Metal Uptake,” Journal of Colloid and Interface Science, Vol. 261, No. 1, pp. 49-54. doi:10.1016/S0021-9797(02)00244-8

[10]   S. Mohan and R. Gandhimathi, “Removal of Heavy Metal Ions from Municipal Solid Waste Leachate Using Coal Fly Ash as An Adsorbent,” Journal of Hazardous Materials, Vol. 169, No. 1-3, 2009, pp. 351-359.

[11]   Z. Milán, E. Sánchez, P. Weiland, R. Borja and A. Marti, “Influence of Different Natural Zeolite Concentrations on the Anaerobic Digestion of Piggery Waste,” Bioresource Technology, Vol. 80 No. 1, 2001, pp. 37-43. doi:10.1016/S0960-8524(01)00064-5

[12]   T. S. Jamil, H. S. Ibrahim, I. H. Abd El-Maksoud, S. T. El-Wakeel, “Application of Zeolite Prepared from Egyptian Kaolin for Removal of Heavy Metals. I. Optimum conditions,” Desalination, Vol. 258, No. 1-3, 2010, pp. 34-40. doi:10.1016/j.desal.2010.03.052

[13]   S. K. Pitcher, R. C. T. Slade and N. I. Ward, “Heavy Metal Removal from Motorway Stormwater Using Zeolites,” Science of The Total Environment, Vol. 334-335, 2004, pp. 161-166. doi:10.1016/j.scitotenv.2004.04.035

[14]   T. Motsi, N. A. Rowson and M. J. H. Simmons, “Adsorption of Heavy Metals from Acid Mine Drainage by Natural Zeolite,” International Journal of Mineral Processing, Vol. 92 No. 1-2, 2009, pp. 42-48. doi:10.1016/j.minpro.2009.02.005

[15]   A. N. Ma, “Treatment of Palm Oil Mill Effluent,” In: G. Singh, K. H. Lim, T. Leng and L. K. David, Ed., Oil Palm and the Environment: A Malaysian Perspective, Malaysian Oil Palm Growers’ Council, Kuala Lampur, 1999, pp. 113-126.

[16]   R. Khalid and W. A. Wan Mustafa, “External Benefits of Environmental Regulation: Resource Recovery and the Utilisation of Effluents,” The Environmentalist, Vol. 12, No. 4, 1992, pp. 277-285. doi:10.1007/BF01267698

[17]   S. Sethupathi, “Removal of Residue Oil from Palm Oil Mill (POME) Using Chitosan,” Universiti Sains Malaysia, Vol. 41, 2004, pp. 962-964.

[18]   N. F. Gray, “Biological of Wastewater Treatment,” Oxford University Press, Oxford, 1992.

[19]   M. A. Shavandi, Z. Haddadian, M. H. S. Ismail, N. Abdullah and Z. Z. Abidin, “Removal of Fe(III), Mn(II) and Zn(II) from Palm Oil Mill Effluent (POME) by Natural Zeolite,” Journal of the Taiwan Institute of Chemical Engineers, Vol. 43, 2012, pp. 750-759. doi:10.1016/j.jtice.2012.02.014

[20]   S. Mohan and R. Gandhimathi, “Removal of Heavy Metal Ions from Municipal Solid Waste Leachate Using Coal Fly Ash as An Adsorbent,” Journal of Hazardous Materials, Vol. 169, No. 1-3, 2009, pp. 351-359.

[21]   E. Erdem, N. Karapinar and R. Donat, “The Removal of Heavy Metal Cations by Natural Zeolites,” Journal of Colloid and Interface Science, Vol. 280, No. 2, 2004, pp. 309-314. doi:10.1016/j.jcis.2004.08.028

[22]   K. K. Pandey, G. Prasad and V. N. Singh, “Copper Removal from Aqueous Solutions by Fly Ash,” Water Research, Vol. 19, No. 7, 1985, pp. 869-873. doi:10.1016/0043-1354(85)90145-9

[23]   M. Ganji, M. Khosravi and R. Rakhshaei, “Biosorption of Pb, Cd, Cu and Zn from the Wastewater by Treated Azollafiliculides with H2O2/MgCl2,” International Journal of Environmental Science and Technology, Vol. 1, No. 4, 2005, pp. 265-271.

[24]   M. B .G. Steinhauser, “Adsorption of Ions onto High Silica Volcanic Glass,” Applied Radiation and Isotopes, Vol. 66, No. 1, 2008, pp. 1-8. doi:10.1016/j.apradiso.2007.07.010

[25]   R. Devi and R. P. Dahiya, “Chemical Oxygen Demand (Cod) Reduction in Domestic Wastewater By Fly Ash And Brick Kiln Ash,” Water, Air, & Soil Pollution, Vol. 174, No. 1-4, 2006, pp. 33-46. doi:10.1007/s11270-005-9022-9

[26]   E. O. Aluyor and O. A. M. Badmus, “COD Removal from Industrial Wastewater Using Activated Carbon Prepared from Animal Horns,” African Journal of Biotechnology,Vol. 7, No. 21, 2008, pp. 3887-3891.

[27]   R. Devi, “Innovative Technology of COD and BOD Reduction from Coffee Processing Wastewater Using Avocado Seed Carbon (ASC),” Water, Air, & Soil Pollution, Vol. 207, 2010, pp. 299-306. doi:10.1007/s11270-009-0137-2

[28]   H. Patel and R. T. Vashi, “Treatment of Textile Wastewaterby Adsorption and Coagulation,” E-Journal of Chemistry, Vol. 7, No. 4, 2010, pp. 1468-1476. doi:10.1155/2010/987620

[29]   C. Saxena and S. Madan, “Evaluation of Adsorbents Efficacy for the Removalof Pollutants from Sugar Mill Effluent,” ARPN Journal of Agricultural and Biological Science, Vol. 7, No. 5, 2012, pp. 325-329.

[30]   S. M. Dal Bosco, R. S. Jimenez and W. A. Carvalho, “Removal of Toxic Metals from Wastewater by Brazilian Natural Scolecite,” Journal of Colloid and Interface Science, Vol. 281, No. 2, 2005, pp. 424-431. doi:10.1016/j.jcis.2004.08.060

[31]   A. Langella, M. Pansini, P. Cappelletti, B. D. Gennaro, M. de’ Gennaro and C. Colella, “NH4+, Cu2+, Zn2+, Cd2+ and Pb2+ Exchange for Na+ in a Sedimentary Clinopti-Lolite, North Sardinia, Italy,” Microporous and Mesoporous Materials, Vol. 37, No. 3, 2000, pp. 337-343. doi:10.1016/S1387-1811(99)00276-0

[32]   C. Semra, “The Removal of Zinc Ions by Natural and Conditioned Clinoptilolites,” Desalination, Vol. 225, No. 1-3, 2008, pp. 41-57.

[33]   M. Al-Anber and Z. A. Al-Anber, “Utilization of Natural Zeolite as Ion-Exchange and Sorbent Material in the Removal of Iron,” Desalination, Vol. 225, No. 1-3, 2008, pp. 70-81. doi:10.1016/j.desal.2007.07.006

[34]   A. Sdiri, T. Higashi, T. Hatta, F. Jamoussi and N. Tase, “Evaluating the Adsorptive Capacity of Montmorillonitic and Calcareous Clays on the Removal of Several Heavy Metals in Aqueous Systems,” Chemical Engineering Journal, Vol. 172, No. 1, 2011, pp. 37-46. doi:10.1016/j.cej.2011.05.015

 
 
Top