SS  Vol.3 No.4 , April 2012
Pre-Application Evaporation of Surgical Preparation Solutions: Does It Matter?
Abstract
Introduction: Surgical site infections (SSIs) remain the most common health care associated infections in the surgical population. Preoperative surgical preparation solutions containing alcohol are believed to be best at eradicating skin microorganisms. The efficacy of alcohol is concentration dependant, with a concentration of greater than 60% most bactericidal. Surgical antisepsis guidelines do not stipulate how long alcoholic preparation solutions can be left out prior to use. Method: 30 ml of Alcoholic Iodine (Iodine 1% in Alcohol 70% (v/v)) and Alcoholic Chlorhexidine (Chlorhex-idine 2% in Alcohol 70% (v/v)) were left to stand in gallipots in an operating theatre equipped with laminar flow. Sam-ples were taken at 0, 30, 60 and 120 minutes and the alcohol content was analyzed. The experiment was repeated 3 times for each time interval. Results: The Alcoholic Iodine group demonstrated significant decrease in alcohol concen-tration, from a mean of 76% (SD 3.6) to a mean of 37.7% (SD 2.9) in only 30 minutes. This effect was sustained, reaching a mean concentration of 26% (SD 2.9) alcohol at 120 minutes. The Alcoholic Chlorhexidine group did not exhibit the same degree of concentration drop, the concentration dropped marginally to 71.5% (SD 2.7) at 120 minutes from 83.4% (SD 0.4). Conclusion: Alcoholic Iodine exhibits significant evaporation under operating room conditions after 30 minutes. Alcoholic Chlorhexidine does not appear to undergo similar losses in concentration. We recommend that alcoholic surgical preparation solutions must be poured immediately prior to use, and must be discarded if left un-covered for more than a few minutes.

Cite this paper
O. Elsewaisy, Y. Ameen and D. Sydenham, "Pre-Application Evaporation of Surgical Preparation Solutions: Does It Matter?," Surgical Science, Vol. 3 No. 4, 2012, pp. 185-188. doi: 10.4236/ss.2012.34035.
References

[1]   N. Fletcher, D. Sofianos, M. Berkes and W. Obremskey, “Prevention of Perioperative Infection,” The Journal of Bone & Joint Surgery, Vol. 89, No. 7, 2007, pp. 1605-1618. doi:10.2106/JBJS.F.00901

[2]   A. Mangram, T. Horan, M. Pearson, L. Silver and W. Jarvis, “U.S. Centers for Disease Control and Prevention. Guideline for Prevention of Surgical Site Infection,” Infection Control and Hospital Epidemiology, Vol. 20, No. 4, 1999, pp. 250-278. doi:10.1086/501620

[3]   J. Zinn, J. Jenkins, V. Swofford, B. Harrelson and S. McCarter, “Intraoperative Patient Skin Prep Agents: Is There a Difference?” AORN Journal, Vol. 92, No. 6, 2010, pp. 662-671. doi:10.1016/j.aorn.2010.07.016

[4]   “Surgical Skin Antisepsis in Operating Theatres. Version 1.0,” Queensland Health, 2011.

[5]   R. Darouiche, M. Wall, K. Itani, M. Otterson, A. Webb, M. Carrick, H. Miller, S. Awad, C. Crosby, M. Mosier, A. AlSharif, and D. Berger, “Chlorhexidine-Alcohol versus Povidone-Iodine for Surgical-Site Antisepsis,” New England Journal of Medicine, Vol. 362, No. 1, 2010, pp. 18-26. doi:10.1056/NEJMoa0810988

[6]   D. Keblish, D. Zurakowski, M. Wilson and C. Chiodo, “Preoperative Skin Preparation of the Foot and Ankle: Bristles and Alcohol Are Better,” Journal of Bone and Joint Surgery, Vol. 87, No. 5, 2005, pp. 986-992. doi:10.2106/JBJS.D.02695

[7]   “Recommended Practices for Preoperative Patient Skin Antisepsis,” Perioperative Standards and Recommended Practices, Association of Perioperative Registered Nurses (AORN), Inc., Denver, 2010.

[8]   H. Morton, “The Relationship of Concentration and Germicidal Efficiency of Ethyl Alcohol,” Annals of the New York Academy of Sciences, Vol. 53, No. 1, 1950, pp. 191-196. doi:10.1111/j.1749-6632.1950.tb31944.x

[9]   G. Kampf, “How Effective Are Hand Antiseptics for the Postcontamination Treatment of Hands When Used as Recommended?” American Journal of Infection Control, Vol. 36, No. 5, 2008, pp. 356-360. doi:10.1016/j.ajic.2007.07.017

[10]   S. Sistla, G. Prabhu, S. Sistla and J. Sadasivan, “Minimizing Wound Contamination in a ‘Clean’ Surgery: Comparison of Chlorhexidine-Ethanol and Povidone-Iodine,” Chemotherapy, Vol. 56, No. 4, 2010, pp. 261-267. doi:10.1159/000319901

[11]   M. Saltzman, G. Nuber, S. Gryzlo, G. Marecek and J. Koh, “Efficacy of Surgical Preparation Solutions in Shoulder Surgery,” Journal of Bone and Joint Surgery, Vol. 91, No. 8, 2009, pp. 1949-1953. doi:10.2106/JBJS.H.00768

[12]   R. Ostrander, M. Botte and M. Brage, “Efficacy of Surgical Preparation Solutions in Foot and Ankle Surgery,” Journal of Bone and Joint Surgery, Vol. 57, 2005, pp. 980-985. doi:10.2106/JBJS.D.01977

[13]   C. Bibbo, D. Patel, R. Gehrmann and S. S. Lin, “Chlorhexidine Provides Superior Skin Decontamination in Foot and Ankle Surgery: A Prospective Randomized Study,” Clinical Orthopaedics & Related Research, Vol. 438, 2005, pp. 204-208. doi:10.1097/01.blo.0000167832.47464.22

[14]   J. Hibbard, G. Mulberry and A. Brady, “A Clinical Study Comparing the Skin Antisepsis and Safety of ChloraPrep, 70% Isopropyl Alcohol, and 2% Aqueous Chlorhexidine,” Journal of Infusion Nursing, Vol. 25, No. 4, 2002, pp. 244-249. doi:10.1097/00129804-200207000-00007

[15]   K. O’Hare, P. Spedding and J. Grimshaw, “Evaporation of the Ethanol and Water Components Comprising a Binary Liquid Mixture,” Asia-Pacific Journal of Chemical Engineering, Vol. 1, No. 2, 1993, pp. 118-128.

 
 
Top